Uji Laboratorium: Analisis Nilai Filtrat High Pressure Water Based Mud pada Sumur Sunset
DOI:
https://doi.org/10.31004/jutin.v8i4.50275Keywords:
LCM, HPWBM, Lost Circulation, FiltrateAbstract
Drilling mud filtration plays an important role in maintaining wellbore stability and preventing excessive fluid loss during the drilling process. If uncontrolled, filtration can damage formations and disrupt operations. This study discusses the effectiveness of High-Pressure Water-Based Mud (HPWBM) with the addition of CaCo3 and Fracseal as an effort to reduce filtration and form a good mud cake. The purpose of this study is to evaluate the filtration performance of HPWBM in various well sizes under HighPressure High-Temperature (HPHT) conditions. This test was conducted in accordance with API standards ( 10 ml/30 minutes). The results show that the filtration rate for the 26“ trajectory is 4.6 ml/30 minutes, the 17-1/2” trajectory is 3.8 ml/30 minutes, the 12-1/4“ trajectory is 4.0 ml/30 minutes, and the 8-1/2” trajectory is 2.4 ml/30 minutes. All values were below the API limit, with a decreasing trend at greater depths. This study confirms that HOWBM with CaCo3 and Fracseal can control filtration, maintain well stability, and improve drilling efficiency and safety.References
Pasarrin, Y. R., Amiruddin, A., Ulfah, B. M., Laby, D. A., & Afifah, R. S. (2024). STUDI LABORATORIUM ANALISIS PENGARUH PENAMBAHAN FRACSEAL DAN KALSIUM KARBONAT (CACO3) UNTUK MENGATASI LOST CIRCULATION TERHADAP LUMPUR PEMBORAN. PETROGAS: Journal Of Energy And Technology, 6(1), 7-11.
Khalid, I., Trisa, W., Novrianti, N., & Novriansyah, A. (2023). ANALYSIS THE EFFECT OF CONCENTRATION AND TEMPERATURE OF BAGASSE AS LOST CIRCULATION MATERIAL (LCM) ON DRILLING MUD RHEOLOGY. PETRO: Jurnal Ilmiah Teknik Perminyakan, 12(3), 131-148.
Kusworo, Z. A., Silviana, S., & Putranto, T. T. (2023). Penggunaan Tepung Tapioka Sebagai Pengganti Bentonit Pada Lumpur Pemboran Berbahan Dasar Air. Jurnal Profesi Insinyur Indonesia, 1(2), 45-51.
Ahmed Hullio, I., Tunio, A. H., Akhtar, W., Memon, M. A., & Gabol, N. M. (2024). Enhancing the Rheological and Filtration Performance of Water-Based Drilling Fluids Using Silane-Coated Aluminum Oxide NPs. ACS omega, 10(1), 955-963
Al-Ziyadi, H., & Verma, A. (2025). Smart Additives for Fluid Loss Control in Water-Based Drilling Fluid: A Review of Recent Developments. Petroleum Research.
Jasper Deebari, U., Iloke, E., Elizabeth, C. N., Kinigoma, B. S., & Jasper, M. Improved Filtration Loss Control of WateBased Mud Using Coconut Shell Nanopowder.
Ramadhan, R. (2016, April). Optimasi penggunaan polymer Ultrahib dalam sistem water base mud di sumur RRX11 lapangan RRX. In Seminar Nasional Cendekiawan 2015. Trisakti University.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Romauli Tiurma Hutabarat, Muhammad Rizqie Fathan, Baiq Maulinda Ulfah
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
